電泳沉積石墨烯導電膜作為染敏太陽電池對電極之研究

Electrophoretic Deposition of Graphene-Based Thin Films as Counter Electrodes for Dye-Sensitized Solar Cells

蔡鎮宇(CHEN-YU TSAI)；張志嘉(ZHI-JIA ZHANG)；黃詩詠(SHIH-YUNG HUANG)；李世傑(SHIH-CHIEH LEE)；姚品全(PIN-CHUAN YAO)

石墨烯 ； 哈莫法 ； 電泳沉積 ； 染敏太陽電池 ； 阻抗分析 ； graphene ； modified Hummer's method ； electrophoretic deposition ； dye-sensitized solar cells ； impedance analysis

科學與工程技術期刊

14卷2期（2018 / 09 / 01）

35 - 45

繁體中文

本研究以化學還原法合成石墨烯片（Graphene platelets），以天然石墨為原料，採用改良式哈莫法（modified Hummers method）製程，增加預氧化程序，並避免使用硝酸鈉，使得製程更為安全與環保。X-ray繞射分析證實石墨烯成品的層間距離增加；原子力顯微鏡照片推估石墨烯的平均厚度為13.782 nm，約為20層天然石墨的層間距離。拉曼分析指出聯胺還原使石墨烯材料中的缺陷與錯位明顯減少，然而無論還原與否，結構的拉曼2D峰值均遠低於天然石墨，顯示成品的層間堆疊不夠規律整齊。合成的石墨烯具有良好的導電性，但可見光透過率較差。於透明導電玻璃基板，以直流電泳在石墨烯懸浮水溶液中沉積石墨烯薄膜。探討不同電泳參數對於薄膜電性的影響，結果指出較高操作電壓與較長沉積時間，可以得到較佳導電性的薄膜。當操作電壓10V，沉積時間60秒時，石墨烯薄膜導電性最好，其片電阻為280.1 ± 4.5 Ω/□，具有載子濃度為4.34 × 10^(17) cm^(-3)；遷移率為569.5 cm^2V^(-1)s^(-1)。電子能譜分析顯示，直流電泳沉積於鍍膜的同時，可將原石墨烯表面的含氧官能基還原成碳環結構。取導電性最佳的鍍膜產品做為染敏太陽電池的對電極，以此所組裝的元件，進行光伏測試，並與傳統的白金對電極比較，結果顯示其DSSC元件的光電轉換效率僅為白金電極所製作元件的20%，如果於石墨烯表面濺鍍一薄層白金，可以大幅提升對電極的活性，此一現象與電化學阻抗分析結果相符。

In the present study, a modified Hummer's method was employed to oxidize natural graphite to graphite oxide. After ultrasonic exfoliation and post-treatment through hydrazine reduction, the as-derived reduced graphene oxide possessed several desirable properties, including an ultra-large surface area, electrical conductivity, optical transparency, and substantial electro-catalytic activity. Although sodium nitrate is an effective oxidant in the traditional Hummer's method, it was obsoleted in the present study due to its ecofriendly synthesis route. The findings of the X-ray diffraction analysis of the as-synthesized samples revealed that the distance between graphene layers was enlarged due to intercalation. On the basis of atomic force microscopy results, the thickness of the as-prepared multilayered graphene was estimated to be 20 layers of the graphitic plane with a sheet resistance of 280.1 ± 4.5 Ω/□ a carrier concentration of 4.34 × 10^(17), and an electric mobility of 9.5 cm^2V^(-1)s^(-1). The as-synthesized graphene was then dispersed in acidic water and coated on an ITO substrate through electrophoretic deposition (EPD), serving as a counter electrode for dye-sensitized solar cells. The photovoltaic characterization indicated that under AM 1.5 G illumination, the cell prepared using the EPD-graphene counter electrode showed insufficient regeneration activity, leading to a low energy conversion efficiency of 0.380%, which was only 20% of the conversion efficiency of a standard platinum film. When a thin layer of sputtered platinum was applied, the performance of the Pt-decorated EPD-graphene counter electrode was substantially enhanced.

1. An, S. J.,Zhu, Y.,Lee, S. H.,Stoller, M. D.,Emilsson, T.,Park, S.,Velamakanni, An J.,Ruoff, R. S.(2010).Thin film fabrication and simultaneous anodic reduction of deposited graphene oxide platelets by electrophoretic deposition.the Journal of Physical Chemistry Letters,1(8),1259-1263.
2. Besra, L.,Liu, M.(2007).A review on fundamentals and applications of electrophoretic deposition (EPD).Progress in Materials Science,52(1),1-61.
3. Biro, L. P.,Nemes-Incze, P.,Lambin, P.(2012).Graphene: nanoscale processing and recent applications.Nanoscale,4(6),1824-1839.
4. Botas, C.,Álvarez, P.,Blanco, P.,Granda, M.,Blanco, C.,Santamaría, R.,Romasanta, L. J.,Verdejo, R.,López-Manchado, M. A.,Menéndez, R.(2013).Graphene materials with different structures prepared from the same graphite by the Hummers and Brodie methods.Carbon,65,156-164.
5. Chen, J.,Yao, B.,Li, C.,Shi, G.(2013).An improved Hummers method for eco-friendly synthesis of graphene oxide.Carbon,64,225-229.
6. Choi, H.,Kim, H.,Hwang, S.,Han, Y.,Jeon, M.(2011).Graphene counter electrodes for dye-sensitized solar cells prepared by electrophoretic deposition.Journal of Materials Chemistry,21(21),7548.
7. Choi, Y. J.,Kim, E.,Han, J.,Kim, J. H.,Gurunathan, S. A.(2016).Novel biomolecule-mediated reduction of graphene oxide: a multifunctional anti-cancer agent.Molecules,21(3),375.
8. Cruz, R.,Tanaka, P.,Mendes, D. A.(2012).Reduced graphene oxide films as transparent counter-electrodes for dye-sensitized solar cells.Solar Energy,86(2),716-724.
9. Dreyer, D. R.,Park, S.,Bielawski, C. W.,Ruoff, R. S.(2010).The chemistry of graphene oxide.Chemical Society reviews,39(1),228-240.
10. Fang, X.,Ma, T.,Guan, G.,Akiyama, M.,Abe, E.(2004).Performances characteristics of dye-sensitized solar cells based on counter electrodes with Pt films of different thickness.Journal of Photochemistry and Photobiology A: Chemistry,164(1),179-182.
11. Ferber, J.,Stangl, R.,Luther, J.(1998).An electrical model of the dye sensitized solar cell.Solar Energy Materials and Solar Cells,53(1-2),29-54.
12. Geim, A. K.(2009).Graphene: status and prospects.Science,324(5934),1530-1534.
13. Geim, A. K.,Novoselov, K. S.(2007).The rise of graphene.Nature materials,6(3),183-191.
14. Gu, W.,Zhang, W.,Li, X.,Zhu, H.,Wei, J.,Li, Z.,Shu, Q.,Wang, C.,Wang, K.,Shen, W.,Kang, F.,Wu, D.(2009).Graphene sheets from worm-like exfoliated graphite.Journal of Materials Chemistry,19(21),3367-3369.
15. Guo, H. L.,Wang, X. F.,Qian, Q. Y.,Wang, F. B.,Xia, X. H.(2009).A Green Approach to the Synthesis of graphene nanosheets.ACS Nano,3(9),2653-2659.
16. Hsieh, C. T.,Yang, B. H.,Chen, Y. F.(2012).Dye-sensitized solar cells equipped with graphene-based counter electrodes with different oxidation levels.Diamond and Related Materials,27-28,68-75.
17. Hummers, W. S.,Offeman, R. E.(1958).Preparation of graphitic oxide.Journal of the American Chemical Society,80(6),1339-1339.
18. Hung, K. H.,Chan, C. H.,Wang, H. W.(2014).Flexible TCO-free counter electrode for dye-sensitized solar cells using graphene nanosheets from a Ti–Ti(III) acid solution.Renewable Energy,66,150-158.
19. Imoto, K.,Takahashi, K.,Yamaguchi, T.,Komura, T.,Nakamura, J. I.,Murata, K.(2003).High-performance carbon counter electrode for dye-sensitized solar cells.Solar Energy Materials and Solar Cells,79(4),459-469.
20. Kay, A.,Grätzel, M.(1996).Low cost photovoltaic modules based on dye sensitized nanocrystalline titanium dioxide and carbon powder.Solar Energy Materials and Solar Cells,44(1),99-117.
21. Kim, H.,Choi, H.,Hwang, S.,Kim, Y.,Jeon, M.(2012).Fabrication and characterization of carbon-based counter electrodes prepared by electrophoretic deposition for dye-sensitized solar cells.Nanoscale research letters,7(1),53.
22. Kim, S. S.,Nah, Y. C.,Noh, Y. Y.,Jo, J.,Kim, D. Y.(2006).Electrodeposited Pt for cost-efficient and flexible dye-sensitized solar cells.Electrochimica Acta,51(18),3814-3819.
23. Kovtyukhova, N. I.,Ollivier, P. J.,Martin, B. R.,Mallouk, T. E.,Chizhik, S. A.,Buzaneva, E. V.,Gorchinskiy, A. D.(1999).Layer-by-layer assembly of ultrathin composite films from micron-sized graphite oxide sheets and polycations.Chemistry of Materials,11(3),771-778.
24. Krishnamoorthy, K.,Veerapandian, M.,Yun, K.,Kim, S. J.(2013).The chemical and structural analysis of graphene oxide with different degrees of oxidation.Carbon,53,38-49.
25. Li, Y. R.,Yao, P. C.(2018).Nanostructured NiOx-coated TiO2 electrodes for dye-sensitized solar cells.Materials Science in Semiconductor Processing,74,352-360.
26. Li, Z. Y.,Akhtar, M. Shaheer,Kuk, J. Hee,Kong, B.S.,Yang, O. B.(2012).Graphene application as a counter electrode material for dye-sensitized solar cell.Materials Letters,86,96-99.
27. Lindström, H.,Holmberg, A.,Magnusson, E.,Malmqvist, L.,Hagfeldt, A.(2001).A new method to make dye-sensitized nanocrystalline solar cells at room temperature.Journal of Photochemistry and Photobiology A: Chemistry,145(1),107-112.
28. Murakami, T. N.,Grätzel, M.(2008).Counter electrodes for DSC: Application of functional materials as catalysts.Inorganica Chimica Acta,361(3),572-580.
29. Nazeeruddin, M. K.,Kay, A.,Rodicio, I.,Humphry-Baker, R.,Mueller, E.,Liska, P.,Vlachopoulos, N.,Graetzel, M.(1993).Conversion of light to electricity by cis-X2bis(2,2'-bipyridyl-4,4'-dicarboxylate) ruthenium(II) charge-transfer sensitizers (X = Cl-, Br-, I-, CN-, and SCN-) on nanocrystalline titanium dioxide electrodes.Journal of the American Chemical Society,115(14),6382-6390.
30. Nguyen, Bich Ha,Nguyen, Van Hieu(2016).Promising applications of graphene and graphene-based nanostructures.Advances in Natural Sciences: Nanoscience and Nanotechnology,7(2),023002.
31. Novoselov, K. S.,Geim, A. K.,Morozov, S. V.,Jiang, D.,Zhang, Y.,Dubonos, S. V.,Grigorieva, I. V.,Firsov, A. A.(2004).Electric field effect in atomically thin carbon films.Science,306(5696),666-669.
32. Sarkar, P.,Nicholson, P. S.(1996).Electrophoretic deposition (EPD): Mechanisms, kinetics, and application to ceramics.Journal of the American Ceramic Society,79(8),1987-2002.
33. Sima, M.,Enculescu, I.,Sima, A.(2011).Preparation of graphene and its application in dye-sensitized solar cells.Optoelectronics and Advanced Materials - Rapid Communications,5(4),414-418.
34. Stankovich, S.,Dikin, D. A.,Dommett, G. H.,Kohlhaas, K. M.,Zimney, E. J.,Stach, E. A.,Piner, R. D.,Nguyen, S. T.,Ruoff, R. S.(2006).Graphene-based composite materials.Nature,442(7100),282-286.
35. Stankovich, S.,Dikin, D. A.,Piner, R. D.,Kohlhaas, K. A.,Kleinhammes, A.,Jia, Y.,Wu, Y.,Nguyen, S. T.,Ruoff, R. S.(2007).Synthesis of graphene-based nanosheets via chemical reduction of exfoliated graphite oxide.Carbon,45(7),1558-1565.
36. Wang, G.,Xing, W.,Zhuo, S.(2009).Application of mesoporous carbon to counter electrode for dye-sensitized solar cells.Journal of Power Sources,194(1),568-573.
37. Wang, M.,Duong, L. D.,Oh, J. S.,Mai, N. T.,Kim, S.,Hong, S.,Hwang, T.,Lee, Y.,Nam, J. D.(2014).Large-area, conductive and flexible reduced graphene oxide (RGO) membrane fabricated by electrophoretic deposition (EPD).ACS applied materials & interfaces,6(3),1747-1753.
38. Xu, M.,Liang, T.,Shi, M.,Chen, H.(2013).Graphene-like two-dimensional materials.Chemical reviews,113(5),3766-3798.
39. Yao, P. C.,Hang, S. T.(2014).Enhancing photovoltaic performances of dye-sensitized solar cells by multi-layered nanostructured titanium oxide photoelectrode.Solar Energy,108,322-330.
40. Yue, G.,Wu, J.,Xiao, Y.,Huang, M.,Lin, J.,Fan, L.,Lan, Z.(2013).Platinum/graphene hybrid film as a counter electrode for dye-sensitized solar cells.Electrochimica Acta,92,64-70.
41. Zhao, G.,Wen, T.,Chen, C.,Wang, X.(2012).Synthesis of graphene-based nanomaterials and their application in energy-related and environmental-related areas.RSC Advances,2(25),9286.
42. Zhitomirsky, I.(2002).Cathodic electrodeposition of ceramic and organoceramic materials: Fundamental aspects.Advances in colloid and interface science,97(1-3),279-317.
43. Zhu, Y.,Murali, S.,Cai, W.,Li, X.,Suk, J. W.,Potts, J. R.,Ruoff, R. S.(2010).Graphene and graphene oxide: synthesis, properties, and applications.Advanced Materials,22(35),3906-3924.

1. 蔡鎮宇,姚品全,李世傑,吳煜華(2023)。以石墨烯懸浮液提升石蠟相變化儲能材料之導熱性。科學與工程技術期刊，19(2)，11-22。